Illustrated how to repair laptop power cords
Your laptop goes dead and you don’t understand why because it’s plugged in. The very first thing you should look for is status LEDs. The transformer brick or ac power adapter usually has a status led on it to show that it’s plugged into a good outlet and is functioning. If the laptop adapter LED is not lit and the cord is firmly seated in both the transformer and the wall outlet, then the AC adapter is probably bad. But troubleshooting most power problems takes a little more effort. Fortunately, it’s also common for the failure to be the power cord itself, as I’ve noted with some Toshiba models. Many HP and Compaq models use “L” connectors which are less prone to failure, and Sony and Dell cords seem more robust as well, but it’s always a possibility. It seems to me I’ve seen “L” connectors on IBM Thinkpads as well.
If the status LEDs on the laptop blink when you wiggle the power cord or if they can be kept on if you position the cord just right, the failure is either the power cord or the power connector inside the laptop. Of the two, you want the problem to be the power cord because it’s much easier to fix. A power cord can look perfectly good (see above) but be broken inside, normally as result of letting it dangle off the back of the laptop when you work on your lap. The length of cable running from the ac power adapter (Dell Inspiron 8200 ac adapter)to the laptop is shielded coaxial cable, with the inner conductor attached to the inner part of the barrel connector and the outer part serving as ground. The actual AC power cord is often detachable from the power adapter and is unlikely to fail as long as it’s seated.
Many power cords also include a large choke, probably a ferrite, which I assume is to prevent RF interference generated by the laptop from leaking back onto the cord and turning the length between the laptop and the power adapter into an antenna. Frankly, I just cut them off on a repair if they are close too the barrel connector. It’s nice to have a reasonable wire stripper so you can strip the coax in one shot rather than worrying away the sheathing with a cheap tool. You want to take about an inch of the outer sheath off and then twist the braid shield together. Some techs like to preload the braid with solder before tacking it to the power connector, but if there’s a tab you can wrap it around first it’s not really necessary.
I prefer to buy new connectors than to try to reuse the original for several reasons. First, the original ac power adapter for laptop will have a molded casing on the connector, and the only way to get it off is to hack away a little at a time with a razor. I’ve done it and effected a repair when I was traveling and had no other choice, but the braided conductor on my Toshiba notebook was soldered directly to the outside of the barrel rather than having its own solder point, like a replacement connector. It’s also very difficult to solder factory connectors without melting the insulator unless you have a hot, fine tip iron. I get my replacement connectors at Radio Shack for a buck or so, bring the original for sizing. The inside and outside diameter have to be an exact match, so you might even want to bring your notebook to the store with you.
If you are working with the cord length still attached to the power adapter (transformer), make sure you slide the shell for the new connector onto the cord and faced the right way before you solder on the connector. Otherwise, you’ll be faced with doing it all over or just taping the heck out of the connector. The length of the barrel connector that fits into the laptop body is somewhat flexible, too long can work, to short and you may be able to back-off a little on the connector shell. To the left, you can see the inner (yellow) of the laptop power cord soldered to the center tab of the barrel conector, and the braid soldered to the outer tab. If you have a heatshrink gun and tubing you can make a much neater job of it than I’m doing here:-)
Obviously, you don’t want the two tabs to touch or it just shorts out, so you can work a little tape around one of the tabs if you are paranoid, but leave room to get the shell on. The shell is actually threaded, as is the connector, so they usually hold together pretty good. Since this particular failure gave me so much grief the first time it happened, I always travel with a spare replacement end for my laptop power cord. While my first replacement is still holding up, should it fail, I can just undo the splice and tape the replacement end on in a matter of minutes. It’s unfortunate that so many people buy a new laptop power adapter or even crack their laptop open and start fooling with the inside receptacle when the problem is just the connector on the power cord.
About the Author
Udtek.com delivers high quality laptop batteries, laptop AC adapters, Laptop keyboards, Lcd chargers, DVD drivers, Scooter chargers and more. Our unique product lines of over 1000 diverse accessory power products and replacement batteries and adapters provide our customers with an extensive selection of the best quality products available.
Nintendo DS Power supply Cable (yellowmangoes.com)
|
|
18.5V 4.9A FOR E-MACHINE LAPTOP AC ADAPTER CHARGER PSU + LEAD POWER CORD CABLE $14.13 |
|
|
HP DV9095 DV6529 DV9625EW LAPTOP CHARGER AC ADAPTER PSU + LEAD POWER CORD CABLE $14.13 |
|
|
90W FOR HP SPARE PART 374791-001 AC ADAPTER CHARGER PSU + LEAD POWER CORD CABLE $14.13 |
|
|
F 4.74A HP Compaq 393954-001 394224-001 LAPTOP CHARGER + LEAD POWER CORD CABLE $14.13 |
|
|
CSA LL-27325 POWER CORD 8FT ! WOW ! $5.99 |
|
|
F HP PAVILION DV6500 DV6700 DV9500 AC ADAPTER POWER PSU + LEAD POWER CORD CABLE $14.13 |
|
|
Coleman Cable 09126 6-Foot 30-Amp 3-Wire Dryer Power Cord $16.23 |
|
|
FOR 19V 4.74A F HP 374473-001 AC ADAPTER CHARGER 1.7MM + LEAD POWER CORD CABLE $14.13 |
|
|
19V 4.74A FOR HP 394224-001 432309-001 AC POWER ADAPTER + LEAD POWER CORD CABLE $14.13 |
|
|
18.5V 4.9A E-MACHINES LSE0202C1890 AC ADAPTER CHARGER + LEAD POWER CORD CABLE $14.13 |
|
|
HP 393954-001 374791-001 LAPTOP CHARGER AC POWER SUPPLY + LEAD POWER CORD CABLE $14.13 |
|
|
BAOHING LL-112007-1 POWER CORD 2M ! WOW ! $2.99 |
|
|
HP COMPAQ PPP012L-S PPP012H-S PPP012D-S POWER CHARGER + LEAD POWER CORD CABLE $14.13 |
|
|
4x Hosa PWD-401 1 ft Daisy Chain IEC Power Cords Cable Piggy Back Plug In NEW $34.99 |
|
|
F. 90W PPP012H-S AC ADAPTER REPLACE HP SPARE 394224-001 + LEAD POWER CORD CABLE $14.13 |
|
|
FOR HP PAVILION DV6848TX DV6853CL DV6853EA ADAPTER PSU + LEAD POWER CORD CABLE $14.13 |
|
|
LAPTOP AC CHARGER FOR HP PAVILION DV1000 DV2000 DV8000 + LEAD POWER CORD CABLE $14.13 |
|
|
FOR HP PAVILION DV 9700 9800 9900 LAPTOP ADAPTER 90W + LEAD POWER CORD CABLE $14.13 |
|
|
19V 4.74A FOR COMPAQ PPP014S LAPTOP AC ADAPTER CHARGER + LEAD POWER CORD CABLE $14.13 |
|
|
FOR HP COMPAQ 394224-001 LAPTOP AC ADAPTER CHARGER PSU + LEAD POWER CORD CABLE $14.13 |
|
|
HP TOUCHSMART TX2-1160EA TX2-1160EO AC ADAPTER CHARGER + LEAD POWER CORD CABLE $14.13 |
|
|
New AC Adapter for HP TouchSmart tx2z-1000 power supply + LEAD POWER CORD CABLE $14.13 |
|
|
Power Cord Cable+Battery Charger for Dell Inspiron 1545 Laptop PA21 XK850 PA-21 $11.99 |
|
|
HP Deskjet 960C Standard Inkjet Printer/Cable/ Power Cord/Page Ct 14234 $18.99 |
|
|
3ft Universal AC Power Distribution Unit Extension C13/C14 Cord / Cable, PC-503 $6.75 |
|
|
AC 10W 2.1A POWER ADAPTER CHARGER + USB DATA CABLE CORD IPAD 2 IPAD 3RD GEN NEW $9.95 |
|
|
170′ 8/4 SOOW SO Portable Power Cord Outdoor Durable Flexible Wire Cable 600V $520.00 |
|
|
Dell 3′ Power Cord Cable PA-10, PA-12 AC-Adapter 3-Prong $2.00 |
|
|
LOT OF 10 SAMSUNG VIZIO TV AC POWER CABLE CORD *NEW* $39.95 |
|
|
Dell 3′ Power Cord Cable PA-10, PA-12 AC-Adapter 2-Prong $2.00 |
|
|
Coleman Cable 12/3 50′ Heavy Duty Outdoor Extension Cord + Power Indicator $30.00 |
|
|
6ft Universal AC Power Distribution Unit Extension C13/C14 Cord / Cable, PC-506 $7.99 |
|
|
HP PhotoSmart C4440 C4450 C4480 electric ac power supply cord adaptor plug cable $17.05 |
|
|
Hosa PWD-401 1 ft Daisy Chain IEC Power Cord Cable Piggy Back Plug In NEW $9.99 |
|
|
HP Deskjet F2100 F2110 F2120 electric ac/dc power supply cord adaptor plug cable $17.05 |
|
|
HP Deskjet F2210 F2224 F2235 F2240 electric ac power adaptor cord cable OEM plug $17.05 |
|
|
Universal Power Cord, 18 AWG, 3-conductor, 6′ cable $4.99 |
|
|
USB Data+Battery Power charging Cable/Cord/Lead For Kodak EasyShare camera M 763 $5.36 |
|
|
USB Data+Battery Power Charging Cable/Cord/Lead fr Olympus camera FE-4030 FE4030 $5.43 |
|
|
Vending machine GFCI Power Cord with 90 degree plug $35.00 |
|
|
Cables To Go 29926-4FT UNIVERSAL POWER CORD $15.66 |
|
|
Coleman Cable 16/3 6′ SPT Power Supply Cord – Gray $199.00 |
|
|
Cables To Go 29810-1.5ft 16 AWG 1-to-2 Power Cord Splitter (NEMA 5-15P to 1 NEMA $18.89 |
|
|
HP Deskjet 895CXI Inkjet Printer/Cable/Power Cord/ Page Count 19020 $15.99 |
|
|
LOT OF 15 UNIVERSAL 3-PRONG STD COMPUTER-PC-PRINTER-SCANNER POWER CORDS-CABLES $24.95 |
|
|
Lot of 10 NEW 6′ 3 Prong Computer Power Cable PC Cord $12.00 |
|
|
2-Prong 8 ft AC Power Cord / Cable made for Korg – NEW $9.99 |
|
|
2-Prong AC Power Cable / Cord for Yamaha CP35 CP-35 Electric Piano $9.99 |
|
|
Koolatron Multi-Purpose Adapter 110AC to 12 Volts DC ( Model AC-15) $29.99 Power your Koolatron(r) Cooler/Warmer at home or office with this AC Adapter. For use with all Koolatron(r) 12V Coolers and warmers and other 12V items. Over-load and over-charge protected…. |
|
|
115V AC Cooling Fan. 120mm x 38mm HS with Power Plug $15.99 Overview The high speed 120 by 120 by 38 millimeter 115V AC axial fan is housed in die cast aluminum with thermoplastic blades. Containing long life dual ball bearings, the fan can run continuously for 67,000 hours and be mounted in any direction. Includes a 4 foot power cord which allows the fan to be plugged into a standard outlet. Cooltron fans are certified by CE, UL, TUV, and RoHS; and found … |
|
|
Cord, 2.5′, 1/2 spacing, fits percolators, rice cookers. $2.76 CO-PC3 cord, 2.5 feet, fits: Percolators, rice cookers, Presto Fry Baby, Presto Percolator 02811, etc if they use a standard cord. Will not replace new style magnetic cords. Pin spacing between terminals is 1/2″. Please compare with your appliance to see it if fits…. |
|
|
Belkin Mini Surge Protector Dual USB Charger $12.99 Protect your electronic devices while traveling…. |
|
|
Belkin 6-Outlet Home/Office Surge Protector $3.45 This Belkin Home/Office Series Surge Protector provides premium power protection for small home appliances, and other connected devices. Our decades of research and development have led us to the release of this breakthrough series. We’ve used advanced design elements, top-quality construction, and superior circuitry and components to provide the most complete protection from power surges, spikes,… |
|
|
Velcro Reusable Self-Gripping Cable Ties, 0.5 Inches x 8 Inches Long, Black, 100 Ties per Pack (91140) $3.79 Ties, Reusable, Adustable, Pre-cut, 8, 100 Count, Black Velcro 91140 Reusable Self-Gripping Cable Ties 1/2 x 8 Long Black 100 Ties per Pack… |
|
|
5 in 1 Card Reader for iPad $0.01 Up for sale is a new gen iPAD/iPAD2 connection kit featuring image/photo transfer via SD,MicroSD reader or USB cable of your camera. In addition,it supports standard keyboard input as well as USB flash drive to iPAD/iPAD2. The Connection Kit supports standard photo formats, such as JPEG and RAW etc. Through this new gen 5-in-1 iPAD/iPAD2 connection kit, the image/photo transfer from your camera to… |
|
|
Belkin USB 2.0 4-Port Ultra-Mini Hub $5.99 The Hi-Speed USB 2.0 4-Port Ultra-Mini Hub provides four downstream USB ports for Plug-and-Play connectivity to your USB 1.1 and USB 2.0 devices. A perfect lightweight travel tool, this compact Hub tucks easily into the pocket of your laptop bag, and requires no extra power supply. It offers an ideal way to connect on the road, and virtually anywhere you need fast, handy access to your USB devices… |
|
|
Power Cord $25.94 Power Cord Power Cable3-pin DC power cable. 2 meters long. For C-Series, E-Series and A65. |
|
|
AC Power Cord Cable – 6 Feet For computer $6.99 AC Power Cord Cable – 6 Feet For computer |
|
|
AC Power Cord Cable – 1 Feet For Computer $5.99 AC Power Cord Cable – 1 Feet For Computer |
|
|
Jumper Power Cord – power cable $34.99 Cisco Jumper Power Cord – Power cable – IEC 320 EN 60320 C13 – IEC 320 EN 60320 C14 – for Catalyst 3560E 3560G 3560V2 3750E 3750V2 |
|
|
First Cable Line Power Cord $2.99 396-006B-RH Length: 6′ Color: Black Agency Approvals: UL RoHS Compliance First Cable Line First Cable Line, Inc Power Cord RoHS Standard Power Cord Yes www.firstcable.com |
|
|
Power Cord Extension – power cable – 10 ft $8.99 StarTech.com Power Cord Extension – Power cable – NEMA 5-15 (F) – NEMA 5-15 (M) – 10 ft – black |
|
|
Universal Power Cord – power cable – 6 ft $8.99 C2G Universal Power Cord – Power cable – IEC 320 EN 60320 C13 (F) – NEMA 5-15 (M) – 6 ft – molded – black |
|
|
Universal Power Cord – power cable – 5 ft $7.99 C2G Universal Power Cord – Power cable – IEC 320 EN 60320 C13 – NEMA 5-15 (M) – 5 ft – molded – black |
|
|
Jumper Power Cord – power cable – 6.6 ft $42.99 Cisco Jumper Power Cord – Power cable – IEC 320 EN 60320 C13 – IEC 320 EN 60320 C14 – 6.6 ft |